 |
Matronics Email Lists
Web Forum Interface to the Matronics Email Lists
|
| View previous topic :: View next topic |
| Author |
Message |
BobbyPaulk(at)comcast.net
Guest
|
 Posted: Mon Jul 25, 2016 11:45 am Post subject: Batteries |
 |
|
Getting back to the Odessy PC680 for a moment.
My first one was purchased in late 2006, removed in 2011 on general principal ( over 4 yrs old. ).
I removed it and installed it in my lawn mower and it is still going strong ( 10 years ).
I just removed my second one over 5 years old because it was too weak to crank after years of cranking a very hard starting engine. Many times I ran it down and had to re-charge it in cooler weather. I fixed the hard starting so I do not anticipate any similar problems.
Odyssey says 3 ~ 10 years service life so we will see.
Bobby ( age 77 )
Zodiac 601 XL "B"
Jabiru 3300 S/N 1141
Sensenich 64" x 51" Prop
Status - Flying 268 hrs.
Do Not Archive
| | - The Matronics AeroElectric-List Email Forum - | | | Use the List Feature Navigator to browse the many List utilities available such as the Email Subscriptions page, Archive Search & Download, 7-Day Browse, Chat, FAQ, Photoshare, and much more:
http://www.matronics.com/Navigator?AeroElectric-List |
|
|
|
| Back to top |
|
 |
markdonahue
Joined: 16 Dec 2012
Posts: 16
Location: bainbridge island washington
|
| Posted: Mon Jul 25, 2016 4:08 pm Post subject: Batteries |
|
|
My Odyssey PC 680 battery in my RV-9A failed to start the engine after two years in service. I removed to the dealer and after bench testing the CCA were down to 70 amp. A new battery solved the problem, but I was disappointed in the short life. I did not have it on a charger and never ran it down. It was just past the 24 month warranty.
Hopefully the new one will last longer.
Mark Donahue
RV 9A
300 hours.
From: owner-aeroelectric-list-server(at)matronics.com [mailto:owner-aeroelectric-list-server(at)matronics.com] On Behalf Of BobbyPaulk(at)comcast.net
Sent: Monday, July 25, 2016 12:43 PM
To: aeroelectric-list
Subject: Batteries
Getting back to the Odessy PC680 for a moment.
My first one was purchased in late 2006, removed in 2011 on general principal ( over 4 yrs old. ).
I removed it and installed it in my lawn mower and it is still going strong ( 10 years ).
I just removed my second one over 5 years old because it was too weak to crank after years of cranking a very hard starting engine. Many times I ran it down and had to re-charge it in cooler weather. I fixed the hard starting so I do not anticipate any similar problems.
Odyssey says 3 ~ 10 years service life so we will see.
Bobby ( age 77 )
Zodiac 601 XL "B"
Jabiru 3300 S/N 1141
Sensenich 64" x 51" Prop
Status - Flying 268 hrs.
Do Not Archive
| | - The Matronics AeroElectric-List Email Forum - | | | Use the List Feature Navigator to browse the many List utilities available such as the Email Subscriptions page, Archive Search & Download, 7-Day Browse, Chat, FAQ, Photoshare, and much more:
http://www.matronics.com/Navigator?AeroElectric-List |
|
_________________
Mark Donahue |
|
| Back to top |
|
|
jmjones2000(at)mindspring
Guest
|
| Posted: Mon Jul 25, 2016 11:55 pm Post subject: Batteries |
|
|
Mark,
Make sure you verify battery charging voltage. Low charging voltage (in the 13s) can cause premature battery failure on the AGM batteries.
Justin
On Jul 25, 2016, at 16:06, Mark Donahue <marktdonahue(at)comcast.net (marktdonahue(at)comcast.net)> wrote:
| Quote: | <![endif]--> <![endif]-->
My Odyssey PC 680 battery in my RV-9A failed to start the engine after two years in service. I removed to the dealer and after bench testing the CCA were down to 70 amp. A new battery solved the problem, but I was disappointed in the short life. I did not have it on a charger and never ran it down. It was just past the 24 month warranty.
Hopefully the new one will last longer.
Mark Donahue
RV 9A
300 hours.
From: owner-aeroelectric-list-server(at)matronics.com (owner-aeroelectric-list-server(at)matronics.com) [mailto:owner-aeroelectric-list-server(at)matronics.com (owner-aeroelectric-list-server(at)matronics.com)] On Behalf Of BobbyPaulk(at)comcast.net (BobbyPaulk(at)comcast.net)
Sent: Monday, July 25, 2016 12:43 PM
To: aeroelectric-list
Subject: Batteries
Getting back to the Odessy PC680 for a moment.
My first one was purchased in late 2006, removed in 2011 on general principal ( over 4 yrs old. ).
I removed it and installed it in my lawn mower and it is still going strong ( 10 years ).
I just removed my second one over 5 years old because it was too weak to crank after years of cranking a very hard starting engine. Many times I ran it down and had to re-charge it in cooler weather. I fixed the hard starting so I do not anticipate any similar problems.
Odyssey says 3 ~ 10 years service life so we will see.
Bobby ( age 77 )
Zodiac 601 XL "B"
Jabiru 3300 S/N 1141
Sensenich 64" x 51" Prop
Status - Flying 268 hrs.
Do Not Archive
|
| | - The Matronics AeroElectric-List Email Forum - | | | Use the List Feature Navigator to browse the many List utilities available such as the Email Subscriptions page, Archive Search & Download, 7-Day Browse, Chat, FAQ, Photoshare, and much more:
http://www.matronics.com/Navigator?AeroElectric-List |
|
|
|
| Back to top |
|
|
Mauledriver(at)nc.rr.com
Guest
|
| Posted: Tue Jul 26, 2016 4:06 am Post subject: Batteries |
|
|
I would 2nd that suggestion having had a lot of experience ruining multiple Odyssey 680s.
 My RV10 carries 2 of them. I had one operating on a bus that ran at 13.4 volts and one on a buss that runs at 14.5+. The batteries on the 13.4 volt circuit lived less than 2 years - an early but slow death.
You can also slowly kill discharged 680s by putting them on a low amp (2 amp charger) but that's well documented in the spec sheets and the AeroE archives.
They are great batteries (light, powerful, long lasting) but the charging requirements are a bit different than plain lead acid batts.
Bill "looking for more 680s to kill" Watson
On 7/26/2016 3:54 AM, Justin Jones wrote:
| Quote: | Mark,
Make sure you verify battery charging voltage. Low charging voltage (in the 13s) can cause premature battery failure on the AGM batteries.Â
Justin
On Jul 25, 2016, at 16:06, Mark Donahue <marktdonahue(at)comcast.net (marktdonahue(at)comcast.net)> wrote:
| Quote: | <![endif]--> <![endif]-->
My Odyssey PC 680 battery in my RV-9A failed to start the engine after two years in service. I removed to the dealer and after bench testing the CCA were down to 70 amp. A new battery solved the problem, but I was disappointed in the short life. I did not have it on a charger and never ran it down. It was just past the 24 month warranty.
Hopefully the new one will last longer.
Mark Donahue
RV 9A
300 hours.
Â
From: owner-aeroelectric-list-server(at)matronics.com (owner-aeroelectric-list-server(at)matronics.com) [mailto:owner-aeroelectric-list-server(at)matronics.com (owner-aeroelectric-list-server(at)matronics.com)] On Behalf Of BobbyPaulk(at)comcast.net (BobbyPaulk(at)comcast.net)
Sent: Monday, July 25, 2016 12:43 PM
To: aeroelectric-list
Subject: Batteries
Â
Getting back to the Odessy PC680 for a moment.
My first one was purchased in late 2006, removed in 2011 on general principal ( over 4 yrs old. ).
I removed it and installed it in my lawn mower and it is still going strong ( 10 years ).
I just removed my second one over 5 years old because it was too weak to crank after years of cranking a very hard starting engine. Many times I ran it down and had to re-charge it in cooler weather. I fixed the hard starting so I do not anticipate any similar problems.
Odyssey says 3 ~ 10 years service life so we will see.
Â
Bobby ( age 77 )
Zodiac 601 XL "B"
Jabiru 3300 S/N 1141
Sensenich 64" x 51" Prop
Status - Flying 268 hrs.
Â
Do Not Archive
|
|
This email has been checked for viruses by Avast antivirus software.
www.avast.com
| | - The Matronics AeroElectric-List Email Forum - | | | Use the List Feature Navigator to browse the many List utilities available such as the Email Subscriptions page, Archive Search & Download, 7-Day Browse, Chat, FAQ, Photoshare, and much more:
http://www.matronics.com/Navigator?AeroElectric-List |
|
|
|
| Back to top |
|
|
markdonahue
Joined: 16 Dec 2012
Posts: 16
Location: bainbridge island washington
|
| Posted: Tue Jul 26, 2016 9:28 am Post subject: Batteries |
|
|
My voltage gauge indicates over 14 volts when the engine is running. I will put my multimeter on it to confirm.
Thanks for the feedback.
Mark
From: owner-aeroelectric-list-server(at)matronics.com [mailto:owner-aeroelectric-list-server(at)matronics.com] On Behalf Of Bill Watson
Sent: Tuesday, July 26, 2016 5:05 AM
To: aeroelectric-list(at)matronics.com
Subject: Re: Batteries
I would 2nd that suggestion having had a lot of experience ruining multiple Odyssey 680s.
My RV10 carries 2 of them. I had one operating on a bus that ran at 13.4 volts and one on a buss that runs at 14.5+. The batteries on the 13.4 volt circuit lived less than 2 years - an early but slow death.
You can also slowly kill discharged 680s by putting them on a low amp (2 amp charger) but that's well documented in the spec sheets and the AeroE archives.
They are great batteries (light, powerful, long lasting) but the charging requirements are a bit different than plain lead acid batts.
Bill "looking for more 680s to kill" Watson
On 7/26/2016 3:54 AM, Justin Jones wrote:
| Quote: |
Mark,
Make sure you verify battery charging voltage. Low charging voltage (in the 13s) can cause premature battery failure on the AGM batteries.
Justin
On Jul 25, 2016, at 16:06, Mark Donahue <marktdonahue(at)comcast.net (marktdonahue(at)comcast.net)> wrote:
| Quote: |
My Odyssey PC 680 battery in my RV-9A failed to start the engine after two years in service. I removed to the dealer and after bench testing the CCA were down to 70 amp. A new battery solved the problem, but I was disappointed in the short life. I did not have it on a charger and never ran it down. It was just past the 24 month warranty.
Hopefully the new one will last longer.
Mark Donahue
RV 9A
300 hours.
From: owner-aeroelectric-list-server(at)matronics.com (owner-aeroelectric-list-server(at)matronics.com) [mailto:owner-aeroelectric-list-server(at)matronics.com (owner-aeroelectric-list-server(at)matronics.com)] On Behalf Of BobbyPaulk(at)comcast.net (BobbyPaulk(at)comcast.net)
Sent: Monday, July 25, 2016 12:43 PM
To: aeroelectric-list
Subject: Batteries
Getting back to the Odessy PC680 for a moment.
My first one was purchased in late 2006, removed in 2011 on general principal ( over 4 yrs old. ).
I removed it and installed it in my lawn mower and it is still going strong ( 10 years ).
I just removed my second one over 5 years old because it was too weak to crank after years of cranking a very hard starting engine. Many times I ran it down and had to re-charge it in cooler weather. I fixed the hard starting so I do not anticipate any similar problems.
Odyssey says 3 ~ 10 years service life so we will see.
Bobby ( age 77 )
Zodiac 601 XL "B"
Jabiru 3300 S/N 1141
Sensenich 64" x 51" Prop
Status - Flying 268 hrs.
Do Not Archive
|
|
[img]cid:~WRD000.jpg[/img]
This email has been checked for viruses by Avast antivirus software.
www.avast.com
| | - The Matronics AeroElectric-List Email Forum - | | | Use the List Feature Navigator to browse the many List utilities available such as the Email Subscriptions page, Archive Search & Download, 7-Day Browse, Chat, FAQ, Photoshare, and much more:
http://www.matronics.com/Navigator?AeroElectric-List |
|
| Description: |
|
| Filesize: |
823 Bytes |
| Viewed: |
5193 Time(s) |
|
_________________
Mark Donahue |
|
| Back to top |
|
|
jmjones2000(at)mindspring
Guest
|
| Posted: Tue Jul 26, 2016 9:50 am Post subject: Batteries |
|
|
Maybe someone will correct me if I am wrong but it needs to be somewhere very close to 14.4.
Justin
On Jul 26, 2016, at 09:26, Mark Donahue <marktdonahue(at)comcast.net (marktdonahue(at)comcast.net)> wrote:
| Quote: | v\:* {behavior:url(#default#VML);} o\:* {behavior:url(#default#VML);} w\:* {behavior:url(#default#VML);} .shape {behavior:url(#default#VML);} <![endif]--> <![endif]--> <![endif]-->
My voltage gauge indicates over 14 volts when the engine is running. I will put my multimeter on it to confirm.
Thanks for the feedback.
Mark
From: owner-aeroelectric-list-server(at)matronics.com (owner-aeroelectric-list-server(at)matronics.com) [mailto:owner-aeroelectric-list-server(at)matronics.com (owner-aeroelectric-list-server(at)matronics.com)] On Behalf Of Bill Watson
Sent: Tuesday, July 26, 2016 5:05 AM
To: aeroelectric-list(at)matronics.com (aeroelectric-list(at)matronics.com)
Subject: Re: AeroElectric-List: Batteries
I would 2nd that suggestion having had a lot of experience ruining multiple Odyssey 680s.
My RV10 carries 2 of them. I had one operating on a bus that ran at 13.4 volts and one on a buss that runs at 14.5+. The batteries on the 13.4 volt circuit lived less than 2 years - an early but slow death.
You can also slowly kill discharged 680s by putting them on a low amp (2 amp charger) but that's well documented in the spec sheets and the AeroE archives.
They are great batteries (light, powerful, long lasting) but the charging requirements are a bit different than plain lead acid batts.
Bill "looking for more 680s to kill" Watson
On 7/26/2016 3:54 AM, Justin Jones wrote:
| Quote: |
Mark,
Make sure you verify battery charging voltage. Low charging voltage (in the 13s) can cause premature battery failure on the AGM batteries.
Justin
On Jul 25, 2016, at 16:06, Mark Donahue <marktdonahue(at)comcast.net (marktdonahue(at)comcast.net)> wrote:
| Quote: |
My Odyssey PC 680 battery in my RV-9A failed to start the engine after two years in service. I removed to the dealer and after bench testing the CCA were down to 70 amp. A new battery solved the problem, but I was disappointed in the short life. I did not have it on a charger and never ran it down. It was just past the 24 month warranty.
Hopefully the new one will last longer.
Mark Donahue
RV 9A
300 hours.
From: owner-aeroelectric-list-server(at)matronics.com (owner-aeroelectric-list-server(at)matronics.com) [mailto:owner-aeroelectric-list-server(at)matronics.com (owner-aeroelectric-list-server(at)matronics.com)] On Behalf Of BobbyPaulk(at)comcast.net (BobbyPaulk(at)comcast.net)
Sent: Monday, July 25, 2016 12:43 PM
To: aeroelectric-list
Subject: Batteries
Getting back to the Odessy PC680 for a moment.
My first one was purchased in late 2006, removed in 2011 on general principal ( over 4 yrs old. ).
I removed it and installed it in my lawn mower and it is still going strong ( 10 years ).
I just removed my second one over 5 years old because it was too weak to crank after years of cranking a very hard starting engine. Many times I ran it down and had to re-charge it in cooler weather. I fixed the hard starting so I do not anticipate any similar problems.
Odyssey says 3 ~ 10 years service life so we will see.
Bobby ( age 77 )
Zodiac 601 XL "B"
Jabiru 3300 S/N 1141
Sensenich 64" x 51" Prop
Status - Flying 268 hrs.
Do Not Archive
|
|
<~WRD000.jpg>
This email has been checked for viruses by Avast antivirus software.
www.avast.com
|
| | - The Matronics AeroElectric-List Email Forum - | | | Use the List Feature Navigator to browse the many List utilities available such as the Email Subscriptions page, Archive Search & Download, 7-Day Browse, Chat, FAQ, Photoshare, and much more:
http://www.matronics.com/Navigator?AeroElectric-List |
|
|
|
| Back to top |
|
|
nuckolls.bob(at)aeroelect
Guest
|
| Posted: Tue Jul 26, 2016 2:22 pm Post subject: Batteries |
|
|
At 12:49 PM 7/26/2016, you wrote:
| Quote: | Maybe someone will correct me if I am wrong but it needs to be somewhere very close to 14.4.
|
Enersys is 'happy' with anything between
14.1 and 14.7 volts. See:
http://tinyurl.com/hb4s7c4
. . . in particular Figure 6 and first
paragraph on page 13.
Bob . . .
| | - The Matronics AeroElectric-List Email Forum - | | | Use the List Feature Navigator to browse the many List utilities available such as the Email Subscriptions page, Archive Search & Download, 7-Day Browse, Chat, FAQ, Photoshare, and much more:
http://www.matronics.com/Navigator?AeroElectric-List |
|
|
|
| Back to top |
|
|
|
|
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum
You cannot attach files in this forum
You can download files in this forum
|
Powered by phpBB © 2001, 2005 phpBB Group
|
Get Email Distribution Too!
FAQ
Search
Memberlist
Usergroups
Register
Profile
Log in to check your private messages
Log in
